Fridge Compressor Repair in Dhaka — Honest Diagnosis, Fair Price
A warm fridge usually means a compressor problem — but not always. We test the thermostat, relay, and wiring before recommending any compressor replacement. If a cheap part fixes it, that is all we charge you for.
Why Refrigerator Compressors Fail in Dhaka
The compressor is the engine of your refrigerator. It pumps refrigerant through the sealed system, absorbing heat from inside the fridge and pushing it out through the condenser coils on the back. When it stops working, your food starts spoiling within hours.
In Dhaka, three things kill fridge compressors faster than anything else: frequent voltage fluctuations that burn out the start relay and motor windings, thick dust clogging the condenser coils that forces the compressor to run nonstop at extreme temperatures, and refrigerant leaks that make the compressor overheat because it is pumping empty lines. Hoque Refrigeration And Engineering Works Ltd. diagnoses the exact cause before we quote you a price.
We carry original and high-quality compatible compressors for all refrigerator brands sold in Bangladesh — Walton, Singer, Minister, Hitachi, LG, Samsung, and more. Whether your fridge needs a simple relay swap or a complete fridge compressor repair in Dhaka, we handle it professionally with a 6-month warranty on parts and labor.
Warning Signs Your Fridge Compressor Is Failing
Compressors rarely die without warning. If you spot these symptoms early, you might save the unit with a minor repair instead of a full replacement.
Fridge Not Cooling At All
The lights are on inside, but the temperature does not drop. The compressor has stopped circulating refrigerant through the system.
Clicking or Buzzing Sound
A repeated click every few minutes means the start relay is trying to engage the compressor but failing. The compressor is drawing locked-rotor amperage.
Compressor Extremely Hot
The black dome at the back of the fridge is too hot to touch. It is running constantly without cooling, which will burn out the windings soon.
Tripping the Breaker
If your refrigerator trips the circuit breaker every time the compressor tries to start, the motor windings may be shorted to ground.
Running Non-Stop
The compressor never cycles off. It runs 24 hours a day but the fridge barely stays cold. Often a gas leak or a failing valve inside the compressor.
Frost on Evaporator, Warm Fridge
A single block of ice forms on part of the evaporator coil while the rest stays warm. The compressor is pumping, but a restriction or leak is starving the system.
If you notice these symptoms, unplug the fridge to prevent further damage. Call our refrigerator repair team in Dhaka for a fast diagnosis.
Dead Compressor or Just a Failed Relay?
In Dhaka, nearly half the “dead compressor” calls we attend turn out to be a failed start relay or thermostat — parts that cost a fraction of a compressor to replace. We test everything before quoting a replacement.
Failed Start Relay or PTC
The start relay gives the compressor motor the initial boost it needs to spin up. When it burns out (very common during Dhaka’s voltage fluctuations), the compressor clicks but will not start. Many technicians skip testing this and condemn the entire compressor — costing you thousands unnecessarily.
- Clicking sound every 2–3 minutes
- Compressor feels warm but is not vibrating
- Fan runs, lights on, but no cooling
- Fix cost: ৳600 – ৳1,500 (takes 20 minutes)
- We test the relay with a multimeter first, always
Compressor Burnout
Internal motor windings short circuit, or mechanical valves break inside the sealed dome. The compressor might draw locked-rotor amperage, trip breakers, or make a deep rattling noise. It cannot be repaired — the entire compressor unit must be replaced with a new one.
- Buzzing or grinding from inside the compressor dome
- Breaker trips the moment the fridge is plugged in
- Windings show open circuit or short to ground on multimeter
- Fix cost: ৳4,500 – ৳10,000+ depending on brand & size
- We replace with original Embraco, Secop, or brand-matched units
We also check for refrigerator gas leaks and thermostat issues before recommending any major work. An honest diagnosis saves you money.
Our Fridge Compressor Replacement Process
No shortcuts. A proper compressor replacement requires precise brazing, vacuuming, and gas charging to ensure it lasts for years.
Complete System Diagnosis
We test the start relay, PTC, thermostat, defrost timer, and compressor windings. If a ৳800 relay fixes the problem, we tell you that — we do not push for a compressor replacement unless it is genuinely necessary.
Transparent Quote and Approval
If the compressor is confirmed dead, we quote you the total cost including the new compressor, refrigerant, filter drier, and labor. No hidden charges added later. You approve the price before we begin any work.
Refrigerant Recovery and Compressor Removal
We safely recover any remaining refrigerant from the system. The failed compressor is cut out, and the filter drier is removed. We flush the lines to eliminate any acid or debris from the old compressor burnout.
New Compressor Installation and Brazing
The new compressor is mounted and connected using nitrogen-flow brazing. This prevents oxidation inside the copper tubing. A new filter drier is installed to absorb any residual moisture.
Deep Vacuum, Leak Test, and Gas Charge
We pull a deep vacuum to remove all air and moisture, then pressure-test with nitrogen to confirm zero leaks. Finally, we weigh in the exact amount of R134a or R600a refrigerant specified by the manufacturer. Your fridge is tested for 24 hours of proper cooling cycles before we consider the job done.
Fridge Compressor Repair and Replacement Pricing in Dhaka
Fair, transparent pricing. The price we quote is the price you pay — no surprise additions.
| Service / Component | Price Range | Details |
|---|---|---|
| Diagnosis Fee | ৳500 | Full electrical test (credited toward repair cost) |
| Start Relay / PTC Replacement | ৳600 – ৳1,500 | Part + labor, fixes most “clicking but won’t start” issues |
| Thermostat Replacement | ৳800 – ৳1,800 | Part + labor, fixes “runs non-stop” or “won’t start” issues |
| Fridge Compressor Replacement | ৳4,500 – ৳10,000 | Original compressor + filter drier + gas + vacuum + labor |
| Deep Freezer Compressor Replacement | ৳6,000 – ৳12,000 | Heavy-duty compressor + filter drier + gas + vacuum + labor |
Prices vary based on fridge brand, capacity, and refrigerant type (R134a or R600a). We provide an exact quote after diagnosis. If your unit needs a fridge gas refill instead, we will tell you that honestly.
Fridge Compressor Service Across Dhaka
Hoque Refrigeration And Engineering Works Ltd. provides compressor diagnostics and replacement in every major neighborhood in Dhaka city.
Why Trust Hoque Refrigeration And Engineering Works Ltd.
A compressor replacement is the most expensive repair your refrigerator will ever need. Here is why Dhaka trusts us to do it honestly.
We Test Relays Before Condemning Compressors
Nearly half our “dead compressor” calls end with a relay or thermostat fix. We always perform a full electrical test before recommending a costly compressor swap.
Original Compressors, No Refurbished Units
Some technicians install used or refurbished compressors to cut costs. We only install brand-new, original spec compressors from Embraco, Secop, Donper, or brand-matched equivalents.
Complete System Recharge Included
Every compressor replacement includes a new filter drier, nitrogen brazing, deep vacuum pull, leak test, and a full weighed refrigerant charge. No hidden extras.
6-Month Warranty on Compressors
Every compressor we install comes with a 6-month warranty covering both the part and the labor. If it fails within this period, we replace it at no charge.
Nearly a Decade of Experience
Since 2015, we have repaired thousands of refrigerators across Dhaka. We know the failure patterns for Walton, Singer, Minister, LG, and Samsung models sold in Bangladesh.
Full Home Appliance Service
Beyond refrigerator repair, we also handle AC compressor repair, washing machine repair, microwave repair, TV repair, and AC installation. One team for your entire home.
Frequently Asked Questions About Fridge Compressor Repair
Honest answers to help you decide whether to repair or replace your refrigerator.
How do I know if my fridge compressor is bad or if it is just the relay?
Is it worth replacing a compressor on an old fridge?
What causes fridge compressors to fail in Dhaka?
How long does a fridge compressor replacement take?
Do you provide a warranty on fridge compressor replacement?
Do you use original or refurbished compressors?
What refrigerant do you use for fridge compressor replacement?
Do you also repair AC compressors?
Get Your Fridge Compressor Checked Today
Do not guess whether it is a relay or a compressor. Our technicians arrive with the right tools to test and give you a clear, honest answer.
Hoque Refrigeration And Engineering Works Ltd.
House-47, Road No. 41, Gulshan Ave, Dhaka 1212
Phone: 01910528424 | Email: contact@acservicedhaka.bd
Service Hours: Every Day 8 AM – 12 AM | Service Area: Dhaka City